YUKEN油研凸輪換向閥DCG-01-2B2-40注塑機配件液壓保險閥

液壓系統故障診斷之故障參數、專用設備、診斷方法

隨著工業技術的不斷發展，液壓系統維修除依靠固有的工作經驗外，越來越多的維修人員開始著手專用的測試儀器與設備，本文以故障參數、專用設備與診斷方法這三點分別予以講解。

一、故障參數

液壓系統故障的主要參數包括壓力、流量、溫度、執行機構（液壓元件）的運行速度、噪聲、油液狀態（受污染程度、黏度等）及外部洩露等，針對不同參數測量時，應根據現場條件（室內或室外）和控制精度的要求，選擇相對應的測試儀表。

①測壓力：通?？煞譅?wèi)普通壓力表、標準壓力表、電接點壓力表與應變式壓力傳感器（可測量液壓管路的瞬時壓力）；

②測流量：通?？煞譅?wèi)橢圓齒輪流量計、渦輪流量計、電遠傳浮子流量計與計量油馬達等；

③測溫度：通?？煞譅?wèi)普通水銀溫度計（測油箱油溫）、電接點水銀溫度計壓力式溫度計與電阻式溫度計（能測量液壓元件的表面溫度）等；

④測油液狀態：通?？煞譅?wèi)顯微鏡、光學比較儀、粒子計數器與粘度計等；

⑤測噪聲：通?？煞譅?wèi)聲級器和譜頻分析器。

二、專用設備

爲了迅速判斷具體的故障原因并及時排除，國內外先后研制出一系列液壓故障測試儀器與設備，部分設備如下：

①手提式液壓測試器：這是一種用于測試液壓系統故障部位的機械裝置，由流量計、壓力表與溫度指示表等組成，具體作用爲測試液壓系統的流量、壓力與溫度等出現的異常故障，其接入管路中的接法可分爲旁通測試與直通測試兩種。

I. 旁通測試

系統的壓力油管應接到測試器的進油口處，回油管需接到測試器的出油口處，測試器上的一隻控制閥主要用于調節和選擇不同的壓力范圍數值；

II.直通測試

將測試器串接于系統的壓力油管上，使之成爲液壓系統的一個臨時組件，當系統正常工作時，可直接測得流量、壓力、溫度的具體數據，以判斷系統是否正常；

IIII.方法比較

通常測試時大多選用直通式，旁通式不適用于做整體測試的封閉型液壓系統，測試時需搭載上分隔組件。

②采用“T”型接頭（三通接頭）：若不測試，需用堵頭將接頭一端堵住；若測試中，需打開并接入測試油管，實質上類似于旁通測試。

I. 當機械正常運轉時，通常會考慮采用這種“T”型接頭測試；

II.其優勢在于不會影響到系統的正産工作，且適用于預防性維護；

III.現在新型T型接頭一般采用磁性旋塞，混入油液中的金屬微粒通過接頭被吸附于磁性旋塞上，若拆卸旋塞予以測試，則可判斷出液壓油的受污染程度；

③液壓系統維修車：這種維修車主要用于軍事工業，方便在現場盡快修複損壞的工程機械液壓系統；

④油泵故障診斷器：該設備可對油泵從外部直接予以故障診斷，且能初步推斷出油泵的剩馀使用壽命。

三、診斷方法

故障診斷的方法種類多樣，小編就較常見的幾大類與大家分享。

一、“四覺”診斷法：所謂四覺，即觸覺、視覺、聽覺與嗅覺這四種，如果故障處于初期階段，可通過這四覺直接判斷并予以處理，這也是目前現場獲得故障信息的簡單途徑；

二、順序推理檢測法：這種診斷法要求主機停止工作，根據診斷出的具體故障位置和涉及的故障范圍（局部或全系統問題），將故障盡量縮小至最小范圍，隨后按順序分析法逐一推理，以判斷故障所在；

三、采用故障測試器的診斷：旁通測試和直通測試

當液壓系統的故障現象是外負載加大時，油缸的動作將趨于緩慢，若想盡快查找出故障所在并加以處理，需進行全面測試組成系統的所有相關元件，用上述的測試器逐一檢測。

（1）旁通測試：先測溢流閥，后測油泵及方向閥

①溢流閥的檢測：爲防止油管被甩出，需按指定油管油路連接測試器，回油管處可用尼龍繩將其扎緊于油箱上。

具體檢測過程如下：

I. 先將測試器的控制閥置于空載位置；

II. 啓動電機以額定轉速運轉；

III. 在流量計的流量讀數未歸零時，緩慢旋緊測試器的控制閥，壓力表讀數應爲該液壓系統溢流閥的固定值；

IV. 按測試要求調節系統的溢流閥（調節后，應重新測試）；

V. 若壓力表指針出現跳動，即說明油泵吸油側存在洩漏問題，需對其先予以修複，避免出現氣蝕現象；

VI. 在壓力值歸零前，流經溢流閥的流量應等同于油泵的額定流量；

VII.在溢流閥完全打開前，若測試器流量計所顯示的數值出現變化，即說明溢流閥存在洩漏問題，此時應全面檢查閥芯與閥座，觀察閥座部位是否有磨損或傷痕，重新測試前，應及時修複或更換。

②油泵的檢測：按要求接好測試器后，油泵與系統將隔開，且不再受溢流閥的控制，因此，其工作壓力不得超過系統最大工作壓力值。

具體測試過程如下：

I.打開測試器的控制閥并啓動電機，使其在額定轉速下運轉；

II.觀察并記錄下測試器在空載時的流量讀數，接著緩慢關閉測試器的控制閥，使測試壓力可逐步上升至系統的額定壓力；

III.若此時流量計上的讀數減少25％，即說明油泵存在故障問題，若流量降低至50％，則可初步斷定液壓系統的故障是油泵所引起；

IV.若壓力表的指針出現跳動，即說明油泵的吸油側存在洩漏問題，爲防止進一步出現氣蝕現象，需對油泵的吸油側及時檢查表并修複。

③方向閥的測試：按管路要求連接旁通測試器，并將回油管扎緊于油箱上。

具體檢測過程如下：

I.打開測試器的控制閥并啓動電機，以額定轉速進行運轉；

II.通過方向控制閥的油液需經過測試器才可流回油箱；

III.爲確保測試器安全使用，從方向控制閥上拆下油管接頭時，需將有機械運動的部件全鎖緊；

IV.記錄下空載時的流量度數，若測得流量值近似于油泵流量，即證明液壓系統正常，故障問題可確定不在前端部分；

V.在壓力達到比系統的額定溢流壓力稍低（通常爲3×10～4×10Pa）前，應將測試器的加載閥（壓力控制閥）緩慢關閉；

VI.在此壓力下，觀察并記錄其流量值。若該流量與空載流量基本相同，說明該方向閥性能基本良好，若流量損失較大，及證明方向閥存在一定問題需及時維修，且可能存在嚴重的洩漏問題。當修複方向控制閥時，應及時洩掉其壓力再進行操作，以免發生意外。

（2）直通測試

該測試包括溢流閥故障、油泵故障、方向控制閥故障、油泵及其他元件故障共四種，針對具體情況予以對應處理。

電磁換向閥：
DSG-01-2B12B-D24-50-L,DSG-01-2B2,DSG-01-2B2-A110-50,DSG-01-2B2-A220-50,DSG-01-2B2-A220-70,DSG-01-2B2B-A220-50
DSG-01-2B2B-D24-50,DSG-01-2B2-D24-70,DSG-01-2B3B-A220-50,DSG-01-2B3B-A220-50(Y),DSG-01-2B3B-A220-N1-50
DSG-01-2B3B-D24-50,DSG-01-2B3B-D24V,DSG-01-2B3-D24-50,DSG-01-2D2,DSG-01-2D2-D24-50,DSG-01-2D2-D24-70
DSG-01-3C2,DSG-01-3C2-A110-50,DSG-01-3C2-D24-N-70,DSG-01-3C4,DSG-01-3C4-A110-50,DSG-01-3C4-A240-70
DSG-01-3C4-D24-50,DSG-01-3C4-D24-70,DSG-01-3C60,DSG-02,DSG-03-2B2,DSG-03-2B2-A110-50,DSG-03-2B2-A200-50
DSG-03-2B2-A220-D24-50,DSG-03-2B2-A220-N1-50,DSG-03-2B2B-A220-50,DSG-03-2B2-D24-50-L,DSG-03-2B3-A110-50
DSG-03-2D2,DSG-03-2D2-A110-50,DSG-03-2D2-A220-N1-50,DSG-03-2D2-D24-50,DSG-03-3C2,DSG-03-3C2-A110-50
DSG-03-3C2-A220-50,DSG-03-3C2-A220-N-50,DSG-03-3C2-A240-N1-50,DSG-03-3C2-D24-50,DSG-03-3C2-D24-N-70
DSG-03-3C2-R220-50,DSG-03-3C4,DSG-03-3C40-D24-50,DSG-03-3C4-A110-50,DSG-03-3C4-A220-50,DSG-03-3C4-A220-N1-50
DSG-03-3C4-D24-50,DSG-03-3C60,DSG-03-3C60-A110-50,DSG-03-3C60-A220-50,DSG-03-3C60-A220-N-50,DSG-03-3C60-D24-50
葉片泵：
150T-116-F-RL-40,150T-116-L-RL-40,150T-48-F-RL-40,150T-48-L-RL-40,150T-61-F-RL-40,150T-61-L-RL-40,150T-75-F-RL-40,150T-75-L-RL-40,150T-94-F-RL-40,150T-94-L-RL-40
50T-12-F-RL-30,50T-17-F-RL-30,50T-36-F-RL-30
A10-F-R-01-B-K-10,A10-F-R-01-C-K-10,A10-F-R-01-H-K-10,A10-LR00-Z500B-12,A10-LR00-Z500C-12,A10-LR00-Z500H-12
A10-L-R-01-B-K-10,A10-L-R-01-C-K-10,A10-L-R-01-H-K-10,A10-LR02B-12,A10-LR02C-12,A10-LR02H-12,A10-LR03B-12,A10-LR03C-12
A10-LR03H-12,A10-LR06B-12,A10-LR06C-12,A10-LR06H-12,A10-LR07B-12,A10-LR07C-12,A10-LR07H-12,A10-LR09B-12,A10-LR09C-12
A10-LR09H-12
A3H100-FR09-22A4K-10,A3H100-FR09-22B6K-10,A3H100-FR09-30A4K-10,A3H100-FR09-30B4K-10,A3H100-FR09-30B6K-10
A3H100-FR09-37A4K-10,A3H100-FR09-37B4K-10,A3H100-FR09-37B6K-10,A3H100-FR09-45A4K-10,A3H100-FR09-45B4K-10
A3H100-FR09-45B6K-10,A3H100-FR09-55A4K-10,A3H100-FR09-55B4K-10,A3H100-LR09-22A4K-10,A3H100-LR09-22B6K-10
A3H100-LR09-30A4K-10,A3H100-LR09-30B4K-10,A3H100-LR09-30B6K-10,A3H100-LR09-37A4K-10,A3H100-LR09-37B4K-10
A3H100-LR09-37B6K-10,A3H100-LR09-45A4K-10,A3H100-LR09-45B4K-10,A3H100-LR09-45B6K-10,A3H100-LR09-55A4K-10
A3H145-FR09-22B6K-10,A3H145-FR09-30A4K-10,A3H145-FR09-30B6K-10,A3H145-FR09-37A4K-10,A3H145-FR09-37A6K-10
A3H145-FR09-37B4K-10,A3H145-FR09-37B6K-10,A3H145-FR09-45A4K-10,A3H145-FR09-45A6K-10,A3H145-FR09-45B4K-10
A3H145-FR09-45B6K-10,A3H145-FR09-55A4K-10,A3H145-FR09-55B4K-10,A3H145-FR09-55B6K-10,A3H145-FR09-75A4K-10
A3H145-FR09-75B4K-10,A3H145-FR09-90B4K-10,A3H145-LR09-22B6K-10,A3H145-LR09-30A4K-10,A3H145-LR09-30B6K-10
A3H145-LR09-37A4K-10,A3H145-LR09-37A6K-10,A3H145-LR09-37B4K-10,A3H145-LR09-37B6K-10,A3H145-LR09-45A4K-10
A3H145-LR09-45A6K-10,A3H145-LR09-45B4K-10,A3H145-LR09-55A4K-10,A3H145-LR09-55B4K-10,A3H145-LR09-55B6K-10
A3H145-LR09-75A4K-10,A3H145-LR09-75B4K-10,A3H145-LR09-90B4K-10,A3H37-FR09-11B4K-10,A3H37-FR09-15B4K-10
A3H37-FR09-22B4K-10,A3H37-LR09-11B4K-10,A3H37-LR09-15B4K-10,A3H37-LR09-22B4K-10,A3H56-FR09-22A4K-10
A3H56-FR09-30A4K-10,A3H56-LR09-22A4K-10,A3H56-LR09-30A4K-10,A3H71-FR09-11A6K-10,A3H71-FR09-15A6K-10
A3H71-FR09-22B4K-10,A3H71-FR09-30A4K-10,A3H71-FR09-30A6K-10,A3H71-FR09-30B4K-10,A3H71-FR09-37A4K-10
A3H71-FR09-37B4K-10,A3H71-FR09-45B4K-10,A3H71-LR09-11A6K-10,A3H71-LR09-22A4K-10,A3H71-LR09-22A6K-10
A3H71-LR09-22B4K-10,A3H71-LR09-30A4K-10,A3H71-LR09-30A6K-10,A3H71-LR09-30B4K-10,A3H71-LR09-37A4K-10
A3H71-LR09-37B4K-10,A3H71-LR09-45B4K-10
AH16-FR01KK-10,AH16-FR01KK-1090,AH16-FR01KS-10,AH16-LR01KK-10，AH37-FR01KK-11,AH37-FR01KK-1190,AH37-FR01KK-20
AH37-FR01KK-2080,AH37-FR01KS-20,AH37-LR01KK-20,AH56-FR01KK-11,AH56-FR01KK-1180,AH56-FR01KK-1190,AH56-FR01KS-10
AH56-FR01KS-11,AH56-LR01KK-11
PV2R1-10-F-RAA-41,PV2R1-10-F-RAB-41,PV2R1-10-F-RAL-41,PV2R1-10-F-RAR-41,PV2R1-10-L-RAA-41,PV2R1-10-L-RAB-41
PV2R1-10-L-RAL-41,PV2R1-10-L-RAR-41,PV2R1-12-F-RAA-41,PV2R1-12-F-RAB-41,PV2R1-12-F-RAL-41,PV2R1-12-F-RAR-41
PV2R1-12-L-RAA-41,PV2R1-12-L-RAB-41,PV2R1-12-L-RAL-41,PV2R1-12-L-RAR-41,PV2R1-14-F-RAA-41,PV2R1-14-F-RAB-41
PV2R1-17-F-RAA-41,PV2R1-19-F-RAA-41,PV2R12-10-26-F-REAA-41,PV2R12-10-26-L-REAA-41,PV2R12-10-33-F-REAA-41
PV2R12-10-33-L-REAA-41,PV2R12-10-41-F-REAA-41,PV2R12-10-41-L-REAA-41,PV2R12-10-47-F-REAA-41
PV2R12-10-47-L-REAA-41,PV2R12-10-53-F-REAA-41,PV2R12-10-53-L-REAA-41,PV2R12-10-59-F-REAA-41
PV2R12-10-59-L-REAA-41,PV2R12-10-65-F-REAA-41,PV2R12-10-65-L-REAA-41,PV2R12-12-26-F-REAA-41
PV2R12-12-26-L-REAA-41,PV2R12-12-33-F-REAA-41,PV2R12-12-33-L-REAA-41,PV2R12-12-41-F-REAA-41
PV2R12-12-41-L-REAA-41,PV2R12-12-47-F-REAA-41,PV2R12-12-47-L-REAA-41,PV2R12-12-53-F-REAA-41
PV2R12-12-53-L-REAA-41,PV2R12-12-59-L-REAA-41,PV2R12-12-65-L-REAA-41,PV2R12-14-26-L-REAA-41
PV2R12-14-33-L-REAA-41,PV2R12-14-41-L-REAA-41,PV2R12-14-47-L-REAA-41,PV2R12-14-53-L-REAA-41
PV2R12-14-59-L-REAA-41,PV2R12-14-65-L-REAA-41,PV2R12-17-26-L-REAA-41,PV2R12-17-33-L-REAA-41
PV2R12-17-41-L-REAA-41,PV2R12-17-47-L-REAA-41,PV2R12-17-53-L-REAA-41,PV2R12-17-59-L-REAA-41
PV2R12-17-65-L-REAA-41,PV2R12-19-26-L-REAA-41,PV2R12-19-33-L-REAA-41,PV2R12-19-41-L-REAA-41
PV2R12-19-47-L-REAA-41,PV2R12-19-53-L-REAA-41,PV2R12-25-47-F-REAA-41,PV2R12-25-53-F-REAA-41
PV2R12-25-59-F-REAA-41,PV2R12-25-65-F-REAA-41,PV2R12-31-26-F-REAA-41,PV2R12-31-33-F-REAA-41
PV2R12-31-41-F-REAA-41,PV2R12-31-47-F-REAA-41,PV2R12-31-53-F-REAA-41,PV2R12-31-59-F-REAA-41
PV2R12-31-65-F-REAA-41,PV2R1-25-F-RAA-41,PV2R12-6-26-F-REAA-41,PV2R12-6-26-L-REAA-41,PV2R12-6-33-F-REAA-41
PV2R12-6-33-L-REAA-41,PV2R12-6-41-F-REAA-41,PV2R12-6-41-L-REAA-41,PV2R12-6-47-F-REAA-41,PV2R12-6-47-L-REAA-41
PV2R12-6-53-F-REAA-41,PV2R12-6-53-L-REAA-41,PV2R12-6-59-F-REAA-41,PV2R12-6-59-L-REAA-41,PV2R12-6-65-F-REAA-41
PV2R12-6-65-L-REAA-41,PV2R12-8-26-F-REAA-41,PV2R12-8-26-L-REAA-41,PV2R12-8-33-F-REAA-41,PV2R12-8-33-L-REAA-41
PV2R12-8-41-F-REAA-41,PV2R12-8-41-L-REAA-41,PV2R12-8-47-F-REAA-41,PV2R12-8-47-L-REAA-41,PV2R12-8-53-F-REAA-41
PV2R12-8-53-L-REAA-41,PV2R12-8-59-F-REAA-41,PV2R12-8-59-L-REAA-41,PV2R12-8-65-F-REAA-41,PV2R12-8-65-L-REAA-41
PV2R1-31-F-RAA41,PV2R1-6-F-RAA-41,PV2R2-26-F-RAA-41,PV2R2-26-F-RAB-41,PV2R2-26-F-RAL-41,PV2R2-26-F-RAR-41
PV2R2-26-L-RAA-41,PV2R2-26-L-RAB-41,PV2R2-26-L-RAL-41,PV2R2-26-L-RAR-41,PV2R2-33-F-RAA-41,PV2R2-33-F-RAB-41
PV2R2-33-F-RAL-41,PV2R2-33-F-RAR-41,PV2R2-33-L-RAA-41,PV2R2-33-L-RAB-41,PV2R2-33-L-RAL-41,PV2R2-33-L-RAR-41
PV2R23-75-153-F-RAAA-41,PV2R23-75-200-F-RAAA-41,PV2R2-41-F-RAA-41,PV2R2-41-F-RAB-41,PV2R2-41-F-RAL-41
PV2R2-41-F-RAR-41,PV2R2-41-L-RAA-41,PV2R2-41-L-RAB-41,PV2R2-41-L-RAL-41,PV2R2-41-L-RAR-41,PV2R24-26-136-F-RAAA-41
PV2R24-26-153-F-RAAA-41,PV2R24-26-184-F-RAAA-41,PV2R24-26-200-F-RAAA-41,PV2R24-26-237-F-RAAA-41
PV2R24-33-136-F-RAAA-41,PV2R24-33-153-F-RAAA-41,PV2R24-33-184-F-RAAA-41,PV2R24-33-200-F-RAAA-41
PV2R24-33-237-F-RAAA-41,PV2R24-41-136-F-RAAA-41,PV2R24-41-153-F-RAAA-41,PV2R24-41-153-F-REAA-40
PV2R24-41-184-F-RAAA-41,PV2R24-41-184-F-REAA-40,PV2R24-41-200-F-RAAA-41,PV2R24-41-200-F-REAA-40
PV2R24-41-237-F-RAAA-41,PV2R24-41-237-F-REAA-40,PV2R24-47-136-F-RAAA-41,PV2R24-47-136-F-REAA-40
PV2R24-47-153-F-RAAA-41,PV2R24-47-153-F-REAA-40,PV2R24-47-184-F-RAAA-41,PV2R24-47-184-F-REAA-40
PV2R24-47-200-F-RAAA-41,PV2R24-47-200-F-REAA-40,PV2R24-47-237-F-RAAA-41,PV2R24-47-237-F-REAA-40
PV2R24-53-136-F-RAAA-41,PV2R24-53-136-F-REAA-40,PV2R24-53-153-F-RAAA-41,PV2R24-53-153-F-REAA-40
PV2R24-53-184-F-RAAA-41,PV2R24-53-184-F-REAA-40,PV2R24-53-200-F-RAAA-41,PV2R24-53-200-F-REAA-40
PV2R24-53-237-F-RAAA-41,PV2R24-53-237-F-REAA-40,PV2R24-59-136-F-RAAA-41,PV2R24-59-136-F-REAA-40
PV2R24-59-153-F-RAAA-41,PV2R24-59-153-F-REAA-40,PV2R24-59-184-F-RAAA-41,PV2R24-59-184-F-REAA-40
PV2R24-59-200-F-RAAA-41,PV2R24-59-200-F-REAA-40,PV2R24-59-237-F-RAAA-41,PV2R24-59-237-F-REAA-40
PV2R24-65-136-F-RAAA-41,PV2R24-65-136-F-REAA-40,PV2R24-65-153-F-RAAA-41,PV2R24-65-153-F-REAA-40
PV2R24-65-184-F-RAAA-41,PV2R24-65-184-F-REAA-40,PV2R24-65-200-F-RAAA-41,PV2R24-65-200-F-REAA-40
PV2R24-65-237-F-REAA-40,PV2R24-75-136-F-RAAA-41,PV2R2-47-F-RAA-41,PV2R2-47-F-RAB-41,PV2R2-47-F-RAL-41
PV2R2-47-F-RAR-41,PV2R2-47-L-RAA-41,PV2R2-47-L-RAB-41,PV2R2-47-L-RAL-41,PV2R2-47-L-RAR-41,PV2R24A-41-FRAAA-10
PV2R2-53-F-RAA-41,PV2R2-53-F-RAB-41,PV2R2-53-F-RAL-41,PV2R2-53-F-RAR-41,PV2R2-53-L-RAA-41,PV2R2-53-L-RAB-41
PV2R2-53-L-RAL-41,PV2R2-53-L-RAR-41,PV2R2-59-F-RAA-41,PV2R2-59-F-RAB-41,PV2R2-65-F-RAA-41,PV2R3-136-F-RAA-31
PV2R34A-76-FRAAA-10,PV2R3-66-L-RAA-31,PV2R3-66-L-RAB-31,PV2R3-66-L-RAL-31,PV2R3-66-L-RAR-31,PV2R3-76-F-RAA-31
PV2R3-76-F-RAB-31,PV2R3-76-F-RAL-31,PV2R3-76-F-RAR-31,PV2R3-76-L-RAA-31,PV2R3-76-L-RAB-31,PV2R3-76-L-RAL-31
PV2R3-76-L-RAR-31,PV2R3-85-F-RAA-31,PV2R3-85-F-RAB-31,PV2R3-85-F-RAL-31,PV2R3-85-F-RAR-31,PV2R3-85-L-RAA-31
PV2R3-85-L-RAB-31,PV2R3-85-L-RAL-31,PV2R3-85-L-RAR-31,PV2R3-94-F-RAA-31,PV2R3-94-F-RAB-31,PV2R3-94-F-RAL-31
PV2R3-94-F-RAR-31,PV2R3-94-L-RAA-31,PV2R3-94-L-RAB-31,PV2R3-94-L-RAL-31,PV2R3-94-L-RAR-31,PV2R4-136-F-RAA-30
PV2R4-153F-RAA-30,PV2R4-184F-RAA-30,PV2R4-200F-RAA-30,PV2R4-237F-RAA-30,PV2R4A-138-FRAA-10
PV2R4A-162-FRAA-10,PV2R4A-193-FRAA-10,PVR50-F-13-R
電液換向閥:
DHG-04-2B2-50  DHG-04-2N2-50  DHG-04-3C2-50  DHG-04-3C40-50  DHG-04-3C4-50  DHG-04-3C5-50  DHG-04-3C60-50 
DHG-06-2B2-50  DHG-06-2N2-50  DHG-06-3C2-50  DHG-06-3C40-50  DHG-06-3C4-50  DHG-06-3C5-50  DHG-06-3C60-50 
DHG-10-3C2-50  DHG-10-3C40-50  DHG-10-3C4-50  DHG-10-3C5-50  DHG-10-3C60-50  DSHG-04-2B2-A110-N1-50 
DSHG-04-2B2-A220-N1-50  DSHG-04-2B2-D24-N1-50  DSHG-04-2N2-A110-N1-50  DSHG-04-2N2-A220-N1-50 
DSHG-04-2N2-D24-N1-50  DSHG-04-3C2-A110-N1-50  DSHG-04-3C2-A220-N1-50  DSHG-04-3C2-D24-N1-50 
DSHG-04-3C3-A110-N1-50  DSHG-04-3C3-A220-N1-50  DSHG-04-3C3-D24-N1-50  DSHG-04-3C40-A110-N1-50 
DSHG-04-3C40-A220-N1-50  DSHG-04-3C40-D24-N1-50  DSHG-04-3C4-A110-N1-50  DSHG-04-3C4-A220-N1-50 
DSHG-04-3C4-D24-N1-50  DSHG-04-3C60-A110-N1-50  DSHG-04-3C60-A220-N1-50  DSHG-04-3C60-D24-N1-50 
DSHG-06-2B2-A110-N1-51  DSHG-06-2B2-A220-N1-51  DSHG-06-2B2-D24-N1-51  DSHG-06-2N2-A110-N1-51 
DSHG-06-2N2-A220-N1-51  DSHG-06-2N2-D24-N1-51  DSHG-06-3C2-A110-N1-51  DSHG-06-3C2-A220-N1-51 
DSHG-06-3C2-D24-N1-51  DSHG-06-3C3-A110-N1-51  DSHG-06-3C3-A220-N1-51  DSHG-06-3C3-D24-N1-51 
DSHG-06-3C40-A110-N1-51  DSHG-06-3C40-A220-N1-51  DSHG-06-3C40-D24-N1-51  DSHG-06-3C4-A110-N1-51 
DSHG-06-3C4-A220-N1-51  DSHG-06-3C4-D24-N1-51  DSHG-06-3C60-A110-N1-51  DSHG-06-3C60-A220-N1-51 
DSHG-06-3C60-D24-N1-51  DSHG-10-2B2-A110-N1-41  DSHG-10-2B2-A220-N1-41  DSHG-10-2B2-D24-N1-41 
DSHG-10-2N2-A110-N1-41  DSHG-10-2N2-A220-N1-41  DSHG-10-2N2-D24-N1-41  DSHG-10-3C2-A110-N1-41 
DSHG-10-3C2-A220-N1-41  DSHG-10-3C2-D24-N1-41  DSHG-10-3C3-A110-N1-41  DSHG-10-3C3-A220-N1-41 
DSHG-10-3C3-D24-N1-41  DSHG-10-3C40-A110-N1-41  DSHG-10-3C40-A220-N1-41  DSHG-10-3C40-D24-N1-41 
DSHG-10-3C4-A110-N1-41  DSHG-10-3C4-A220-N1-41  DSHG-10-3C4-D24-N1-41  DSHG-10-3C60-A110-N1-41 
DSHG-10-3C60-A220-N1-41  DSHG-10-3C60-D24-N1-41   

單向閥：
DT-01-22
疊加式溢流閥 :
MBA-01-C-30,MBA-01-H-30,MBA-03-B-20,MBA-03-B-30,MBA-03-H-20,MBA-03-H-30
MBB-01-C-30,MBB-01-H-30,MBB-03-B-20,MBB-03-B-30,MBB-03-H-20,MBB-03-H-30
MBP-01-C-30,MBP-01-H-30,MBP-03-B-20,MBP-03-B-30,MBP-03-H-20,MBP-03-H-30
MBW-03-B-20,MBW-03-B-30,MBW-03-H-20,MBW-03-H-30
疊加式單向節流閥：
MSA-01-X-30 MSA-01-X-50 MSA-01-Y-30 MSA-01-Y-50 MSA-03-X-30 MSA-03-X-40 MSA-03-Y-30 MSA-03-Y-40
MSB-01-X-30 MSB-01-X-50 MSB-01-Y-30 MSB-01-Y-50 MSB-03-X-30 MSB-03-X-40 MSB-03-Y-30 MSB-03-Y-40
MSW-01-X-30 MSW-01-X-50 MSW-01-XY-30 MSW-01-XY-50 MSW-01-Y-30 MSW-01-Y-50 MSW-01-YX-30 MSW-01-YX-50
MSW-03-X-30 MSW-03-X-40 MSW-03-Y-30 MSW-03-Y-40  
溢流閥:
BF-10-*-32
BG-03 BG-03-*-32 BG-03-32 BG-03-V-32 BG-06 BG-06-*-32 BG-06-32 BG-10-*-32 BG-10-32
BST-03-2B*-AC/DC-46 BST-03-3c*-AC/DC-46
Bt-03-*-22 BT-03-32 Bt-06-*-22 BT-06-32 Bt-10-*-22
DG-01-22 DG-02-*-22 DT-01-22 DT-02-*-22
S-BG-03-*-l-40 S-BG-06-*-l-40 
液壓單向閥：
CRG-03，CRG-06，CRG-10
液壓管式溢流閥:
BT-04;BT-06,BT-03-32,BT-10-32，BT-04
先導式溢流閥:
RV-10，RV-03 ,RV-06T,RV-04T,
電磁溢流閥:
BSG-03-2B2-A110-N1-L-46 BSG-03-2B2-A110-N1-R-46 BSG-03-2B2-A220-N1-L-46 BSG-03-2B2-A220-N1-R-46
BSG-03-2B2B-A110-N1-L-46 BSG-03-2B2B-A110-N1-R-46 BSG-03-2B2B-A220-N1-L-46 BSG-03-2B2B-A220-N1-R-46
BSG-03-2B2B-D24-N1-L-46 BSG-03-2B2B-D24-N1-R-46 BSG-03-2B2-D24-N1-L-46 BSG-03-2B2-D24-N1-R-46
BSG-03-2B3A-A110-N1-L-46 BSG-03-2B3A-A110-N1-R-46 BSG-03-2B3A-A220-N1-L-46 BSG-03-2B3A-A220-N1-R-46
BSG-03-2B3A-D24-N1-L-46 BSG-03-2B3A-D24-N1-R-46 BSG-03-2B3B-A110-N1-L-46 BSG-03-2B3B-A110-N1-R-46
BSG-03-2B3B-A220-N1-L-46 BSG-03-2B3B-A220-N1-R-46 BSG-03-2B3B-D24-N1-L-46 BSG-03-2B3B-D24-N1-R-46
BSG-03-3C2-A110-N1-L-46 BSG-03-3C2-A110-N1-R-46 BSG-03-3C2-A220-N1-L-46 BSG-03-3C2-A220-N1-R-46
BSG-03-3C2-D24-N1-L-46 BSG-03-3C2-D24-N1-R-46 BSG-03-3C3-A110-N1-L-46 BSG-03-3C3-A110-N1-R-46
BSG-03-3C3-A220-N1-L-46 BSG-03-3C3-A220-N1-R-46 BSG-03-3C3-D24-N1-L-46 BSG-03-3C3-D24-N1-R-46
BSG-06-2B2-A110-N1-L-46 BSG-06-2B2-A110-N1-R-46 BSG-06-2B2-A220-N1-L-46 BSG-06-2B2-A220-N1-R-46
BSG-06-2B2B-A110-N1-L-46 BSG-06-2B2B-A110-N1-R-46 BSG-06-2B2B-A220-N1-L-46 BSG-06-2B2B-A220-N1-R-46
BSG-06-2B2B-D24-N1-L-46 BSG-06-2B2B-D24-N1-R-46 BSG-06-2B2-D24-N1-L-46 BSG-06-2B2-D24-N1-R-46
BSG-06-2B3A-A110-N1-L-46 BSG-06-2B3A-A110-N1-R-46 BSG-06-2B3A-A220-N1-L-46 BSG-06-2B3A-A220-N1-R-46
BSG-06-2B3A-D24-N1-L-46 BSG-06-2B3A-D24-N1-R-46 BSG-06-2B3B-A110-N1-L-46 BSG-06-2B3B-A110-N1-R-46
BSG-06-2B3B-A220-N1-L-46 BSG-06-2B3B-A220-N1-R-46 BSG-06-2B3B-D24-N1-L-46 BSG-06-2B3B-D24-N1-R-46
BSG-06-3C2-A110-N1-L-46 BSG-06-3C2-A110-N1-R-46 BSG-06-3C2-A220-N1-L-46 BSG-06-3C2-A220-N1-R-46
BSG-06-3C2-D24-N1-L-46 BSG-06-3C2-D24-N1-R-46 BSG-06-3C3-A110-N1-L-46 BSG-06-3C3-A110-N1-R-46
BSG-06-3C3-A220-N1-L-46 BSG-06-3C3-A220-N1-R-46 BSG-06-3C3-D24-N1-L-46 BSG-06-3C3-D24-N1-R-46
BSG-10-2B2-A110-N1-L-46 BSG-10-2B2-A110-N1-R-46 BSG-10-2B2-A220-N1-L-46 BSG-10-2B2B-A110-N1-L-46
BSG-10-2B2B-A110-N1-R- BSG-10-2B2B-A220-N1-L-46 BSG-10-2B2B-D24-N1-L- BSG-10-2B2-D24-N1-L-46
BSG-10-2B3A-A110-N1-L-46 BSG-10-2B3A-A110-N1-R-46 BSG-10-2B3A-A220-N1-L-46 BSG-10-2B3A-D24-N1-L-46
BSG-10-2B3B-A110-N1-L-46 BSG-10-2B3B-A110-N1-R-46 BSG-10-2B3B-A220-N1-L-46 BSG-10-2B3B-D24-N1-L-46
BSG-10-3C2-A110-N1-L-46 BSG-10-3C2-A220-N1-L-46 BSG-10-3C2-D24-N1-L-46 BSG-10-3C3-A110-N1-L-46
BSG-10-3C3-A220-N1-L-46 BSG-10-3C3-D24-N1-L-46 
BST-03-2B2-D24-N1-L-46       BST-03-2B2-A110-N1-L-46       BST-06-2B3B-A220-N1-L-46
BST-03-2B2-A220-N1-L-46      BST-03-2B2-A240-N1-L-46       BST-03-2B3B-D24-N1-L-46 
BST-03-2B3B-A110-N1-L-46     BST-03-2B3B-A220-N1-L-46      BST-03-2B3B-A240-N1-L-46
BST-06-2B2-D24-N1-L-46       BST-06-2B2-A110-N1-L-46       BST-06-2B2-A220-N1-L-46 
BST-06-2B2-A240-N1-L-46      BST-06-2B3B-D24-N1-L-46       BST-06-2B3B-A110-N1-L-46
SBSG-03-3C2-A110-N1-L-51 SBSG-03-3C2-A110-N1-R-51 SBSG-03-3C3-A110-N1-L-51 SBSG-03-3C3-A110-N1-R-51
SBSG-03-2B2-A110-N1-L-51 SBSG-03-2B2-A110-N1-R-51 SBSG-03-2B3A-A110-N1-L-51 SBSG-03-2B3A-A110-N1-R-51
SBSG-03-2B2B-A110-N1-L-51 SBSG-03-2B2B-A110-N1-R-51 SBSG-03-3C2-A220-N1-L-51 SBSG-03-3C2-A220-N1-R-51
SBSG-03-3C3-A220-N1-L-51 SBSG-03-3C3-A220-N1-R-51 SBSG-03-2B2-A220-N1-L-51 SBSG-03-2B2-A220-N1-R-51
SBSG-03-2B3A-A220-N1-L-51 SBSG-03-2B3A-A220-N1-R-51 SBSG-03-2B2B-A220-N1-L-51 SBSG-03-2B2B-A220-N1-R-51
SBSG-03-3C2-D24-N1-L-51 SBSG-03-3C2-D24-N1-R-51 SBSG-03-3C3-D24-N1-L-51 SBSG-03-3C3-D24-N1-R-51
SBSG-03-2B2-D24-N1-L-51 SBSG-03-2B2-D24-N1-R-51 SBSG-03-2B3A-D24-N1-L-51 SBSG-03-2B3A-D24-N1-R-51
SBSG-03-2B2B-D24-N1-L-51 SBSG-03-2B2B-D24-N1-R-51
比例閥：
EBG-03 EBG-06
EDG-01V-B-PNT15-51 EDG-01V-H-1-PIT15-5103
EFBG-03-125-C-20T EFBG-03-125-C-60T EFBG-03-160-C-20T EFBG-06-250-H-20T

液控單向閥：
CPDG-03-30-20  CPDG-03-50-20  CPDG-03-75-20  CPDG-03-E-30-20  CPDG-03-E-50-20  CPDG-03-E-75-20  CPDG-06-30-20 
CPDG-06-50-20  CPDG-06-75-20  CPDG-06-E-30-20  CPDG-06-E-50-20  CPDG-06-E-75-20  CPDG-10-30-20  CPDG-10-50-20 
CPDG-10-75-20  CPDG-10-E-30-20  CPDG-10-E-50-20  CPDG-10-E-75-20 

CPDT-03-30-20  CPDT-03-50-20  CPDT-03-75-20  CPDT-03-E-30-20  CPDT-03-E-50-20  CPDT-03-E-75-20  CPDT-06-30-20 
CPDT-06-50-20  CPDT-06-75-20  CPDT-06-E-30-20  CPDT-06-E-50-20  CPDT-06-E-75-20  CPDT-10-30-20  CPDT-10-50-20 
CPDT-10-75-20  CPDT-10-E-30-20  CPDT-10-E-50-20  CPDT-10-E-75-20 

CPG-03-30-20  CPG-03-50-20  CPG-03-75-20  CPG-03-E-30-20  CPG-03-E-50-20  CPG-03-E-75-20  CPG-06-30-20  CPG-06-50-20 
CPG-06-75-20  CPG-06-E-30-20  CPG-06-E-50-20  CPG-06-E-75-20  CPG-10-30-20  CPG-10-50-20  CPG-10-75-20  CPG-10-E-30-20 
CPG-10-E-50-20  CPG-10-E-75-20 

CPT-03-30-20  CPT-03-50-20  CPT-03-75-20  CPT-03-E-30-20  CPT-03-E-50-20  CPT-03-E-75-20  CPT-06-30-20  CPT-06-50-20 
CPT-06-75-20  CPT-06-E-30-20  CPT-06-E-50-20  CPT-06-E-75-20  CPT-10-30-20  CPT-10-50-20  CPT-10-75-20  CPT-10-E-30-20 
CPT-10-E-50-20  CPT-10-E-75-20   
凸輪換向閥：
DCG-01-2B2-40