JGH臺灣久岡電磁閥4WE-10D/E-W220/50-20 10A/B/C/Y/-G24久岡

液壓油泵的調試及注意事項

一臺新的液壓系統組裝完成后一般都要經過調試好后才能投入工作，今天主要跟大家講下液壓油泵的調試方法與注意要點。 液壓油泵安裝完成后，必須經過泵的檢查，調試，觀察泵的工作是否正常，那如何去檢查、調試液壓泵是否工作正常呢？ 下面一起來看看吧！

(1)檢查油泵的旋轉方向應與泵體上標牌所指示的方向相符合，不得接反。

(2)用手轉動聯軸節，應感輕快，受力均勻，以識別泵的安裝是否正常。

(3)檢查系統中的安全閥是否在調定的許可壓力上。

(4)檢查液壓系統有沒有卸荷回路，能否造成滿載啓動和停車，以至降低泵的使用壽命，并使電機過載。

(5)油泵首次試車前，應在排油口灌滿油液，使泵內有油，以免泵啓動時因干摩擦損壞元件，同時將安全閥打開。

(6)油泵在工作前應進行不少于10min的空負荷運轉.檢查泵的運轉聲音是否正常和液流的方向是否正確。如果正常，則可進行帶負荷試車。首先進行低負荷運轉，將溢流閥的壓力調整到2.0MPa以下轉動10一15min,檢查系統的動作、外洩漏、噪聲、溫升等是否正常。如果一切正常，可將溢流閥的壓力調整至液壓系統的安全保護壓力，再使液壓系統卸荷。若不正常，則查找原因，再做調試和試車，直到油泵正常工作爲止。

電磁換向閥：
4WE-10A/E-G24-20 4WE-10A/E-W110-20 4WE-10A/E-W220-20 4WE-10A/E-W240-20 4WE-10B/E-G24-20 4WE-10B/E-W110-20
4WE-10B/E-W220-20 4WE-10B/E-W240-20 4WE-10C/E-G24-20 4WE-10C/E-W110-20 4WE-10C/E-W220-20 4WE-10C/E-W240-20
4WE-10D/E-G24-20 4WE-10D/E-W110-20 4WE-10D/E-W220-20 4WE-10D/E-W240-20 4WE-10E/E-G12-20 4WE-10E/E-W110-20
4WE-10E/E-W240-20 4WE-10F/E-G12-20 4WE-10F/E-W110-20 4WE-10F/E-W240-20 4WE-10G/E-G12-20 4WE-10G/E-W110-20
4WE-10G/E-W240-20 4WE-10P/E-W240-20 4WE-10V/E-W240-20 4WE-6-A/E-G12-20 4WE-6-A/E-G24-20 4WE-6-A/E-W110-20
4WE-6-A/E-W220-20 4WE-6-A/E-W240-20 4WE-6-AO/E-G12-20 4WE-6-AO/E-G24-20 4WE-6-AO/E-W110-20
4WE-6-AO/E-W220-20 4WE-6-AO/E-W240-20 4WE-6-AOF/E-G12-20 4WE-6-AOF/E-G24-20 4WE-6-AOF/E-W110-20
4WE-6-AOF/E-W220-20 4WE-6-AOF/E-W240-20 4WE-6-B/E-G12-20 4WE-6-B/E-G24-20 4WE-6-B/E-W110-20 4WE-6-B/E-W220-20
4WE-6-B/E-W240-20 4WE-6-BO/E-G12-20 4WE-6-BO/E-G24-20 4WE-6-BO/E-W110-20 4WE-6-BO/E-W220-20
4WE-6-BO/E-W240-20 4WE-6-BOF/E-G12-20 4WE-6-BOF/E-G24-20 4WE-6-BOF/E-W110-20 4WE-6-BOF/E-W220-20
4WE-6-BOF/E-W240-20 4WE-6-C/E-G12-20 4WE-6-C/E-G24-20 4WE-6-C/E-W110-20 4WE-6-C/E-W220-20 4WE-6-C/E-W240-20
4WE-6-CO/E-G12-20 4WE-6-CO/E-G24-20 4WE-6-CO/E-W110-20 4WE-6-CO/E-W220-20 4WE-6-CO/E-W240-20
4WE-6-COF/E-G12-20 4WE-6-COF/E-G24-20 4WE-6-COF/E-W110-20 4WE-6-COF/E-W220-20 4WE-6-COF/E-W240-20
4WE-6-D/E-G12-20 4WE-6-D/E-G24-20 4WE-6-D/E-W110-20 4WE-6-D/E-W220-20 4WE-6-D/E-W240-20 4WE-6-DO/E-G12-20
4WE-6-DO/E-G24-20 4WE-6-DO/E-W110-20 4WE-6-DO/E-W220-20 4WE-6-DO/E-W240-20 4WE-6-DOF/E-G12-20
4WE-6-DOF/E-G24-20 4WE-6-DOF/E-W110-20 4WE-6-DOF/E-W220-20 4WE-6-DOF/E-W240-20 4WE-6-E/E-G12-20
4WE-6-E/E-G24-20 4WE-6-E/E-W110-20 4WE-6-E/E-W220-20 4WE-6-E/E-W240-20 4WE-6-EO/E-G12-20 4WE-6-EO/E-G24-20
4WE-6-EO/E-W110-20 4WE-6-EO/E-W240-20 4WE-6-EOF/E-G12-20 4WE-6-EOF/E-G24-20 4WE-6-EOF/E-W110-20
4WE-6-EOF/E-W220-20 4WE-6-EOF/E-W240-20 4WE-6-F/E-G12-20 4WE-6-F/E-G24-20 4WE-6-F/E-W110-20 4WE-6-F/E-W220-20
4WE-6-F/E-W240-20 4WE-6-FO/E-G12-20 4WE-6-FO/E-G24-20 4WE-6-FO/E-W110-20 4WE-6-FO/E-W220-20
4WE-6-FO/E-W240-20 4WE-6-FOF/E-G12-20 4WE-6-FOF/E-G24-20 4WE-6-FOF/E-W110-20 4WE-6-FOF/E-W220-20
4WE-6-FOF/E-W240-20 4WE-6-G/E-G12-20 4WE-6-G/E-G24-20 4WE-6-G/E-W110-20 4WE-6G/E-W220/50-20 4WE-6-G/E-W220-20
4WE-6-G/E-W240-20 4WE-6-GO/E-G12-20 4WE-6-GO/E-G24-20 4WE-6-GO/E-W110-20 4WE-6-GO/E-W220-20
4WE-6-GO/E-W240-20 4WE-6-GOF/E-G12-20 4WE-6-GOF/E-G24-20 4WE-6-GOF/E-W110-20 4WE-6-GOF/E-W220-20
4WE-6-GOF/E-W240-20 4WE-6-H/E-G12-20 4WE-6-H/E-G24-20 4WE-6-H/E-W110-20 4WE-6-H/E-W220-20 4WE-6-H/E-W240-20
4WE-6-HA/E-W240-20 4WE-6-HO/E-G12-20 4WE-6-HO/E-G24-20 4WE-6-HO/E-W110-20 4WE-6-HO/E-W220-20
4WE-6-HO/E-W240-20 4WE-6-HOF/E-G12-20 4WE-6-HOF/E-G24-20 4WE-6-HOF/E-W110-20 4WE-6-HOF/E-W220-20
4WE-6-HOF/E-W240-20 4WE-6-J/E-G12-20 4WE-6-J/E-G24-20 4WE-6-J/E-W110-20 4WE-6-J/E-W220/50-20 4WE-6-J/E-W220-20
4WE-6-J/E-W240-20 4WE-6-JO/E-G12-20 4WE-6-JO/E-G24-20 4WE-6-JO/E-W110-20 4WE-6-JO/E-W220-20
4WE-6-JO/E-W240-20 4WE-6-JOF/E-G12-20 4WE-6-JOF/E-G24-20 4WE-6-JOF/E-W110-20 4WE-6-JOF/E-W220-20
4WE-6-JOF/E-W240-20 4WE-6-L/E-G12-20 4WE-6-L/E-G24-20 4WE-6-L/E-W110-20 4WE-6-L/E-W220-20 4WE-6-L/E-W240-20
4WE-6-LO/E-G12-20 4WE-6-LO/E-G24-20 4WE-6-LO/E-W110-20 4WE-6-LO/E-W220-20 4WE-6-LO/E-W240-20
4WE-6-LOF/E-G12-20 4WE-6-LOF/E-G24-20 4WE-6-LOF/E-W110-20 4WE-6-LOF/E-W220-20 4WE-6-LOF/E-W240-20
4WE-6-M/E-G12-20 4WE-6-M/E-G24-20 4WE-6-M/E-W110-20 4WE-6-M/E-W220-20 4WE-6-M/E-W240-20 4WE-6-MO/E-G12-20
4WE-6-MO/E-G24-20 4WE-6-MO/E-W110-20 4WE-6-MO/E-W220-20 4WE-6-MO/E-W240-20 4WE-6-MOF/E-G12-20
4WE-6-MOF/E-G24-20 4WE-6-MOF/E-W110-20 4WE-6-MOF/E-W220-20 4WE-6-MOF/E-W240-20 4WE-6-P/E-G12-20
4WE-6-P/E-G24-20 4WE-6-P/E-W110-20 4WE-6-P/E-W220-20 4WE-6-P/E-W240-20 4WE-6-PO/E-G12-20 4WE-6-PO/E-G24-20
4WE-6-PO/E-W110-20 4WE-6-PO/E-W220-20 4WE-6-PO/E-W240-20 4WE-6-POF/E-G12-20 4WE-6-POF/E-G24-20
4WE-6-POF/E-W110-20 4WE-6-POF/E-W220-20 4WE-6-POF/E-W240-20 4WE-6-Q/E-G12-20 4WE-6-Q/E-G24-20
4WE-6-Q/E-W110-20 4WE-6-Q/E-W220-20 4WE-6-Q/E-W240-20 4WE-6-QO/E-G12-20 4WE-6-QO/E-G24-20
4WE-6-QO/E-W110-20 4WE-6-QO/E-W220-20 4WE-6-QO/E-W240-20 4WE-6-R/E-G12-20 4WE-6-R/E-G24-20 4WE-6-R/E-W110-20
4WE-6-R/E-W220-20 4WE-6-R/E-W240-20 4WE-6-RO/E-G12-20 4WE-6-RO/E-G24-20 4WE-6-RO/E-W110-20 4WE-6-RO/E-W220-20
4WE-6-RO/E-W240-20 4WE-6-ROF/E-G12-20 4WE-6-ROF/E-G24-20 4WE-6-ROF/E-W110-20 4WE-6-ROF/E-W220-20
4WE-6-ROF/E-W240-20 4WE-6-T/E-G12-20 4WE-6-T/E-G24-20 4WE-6-T/E-W110-20 4WE-6-T/E-W220-20 4WE-6-T/E-W240-20
4WE-6-TO/E-G12-20 4WE-6-TO/E-G24-20 4WE-6-TO/E-W110-20 4WE-6-TO/E-W220-20 4WE-6-TO/E-W240-20
4WE-6-TOF/E-G12-20 4WE-6-TOF/E-G24-20 4WE-6-TOF/E-W110-20 4WE-6-TOF/E-W220-20 4WE-6-TOF/E-W240-20
4WE-6-U/E-G12-20 4WE-6-U/E-G24-20 4WE-6-U/E-W110-20 4WE-6-U/E-W220-20 4WE-6-U/E-W240-20 4WE-6-UO/E-G12-20
4WE-6-UO/E-G24-20 4WE-6-UO/E-W110-20 4WE-6-UO/E-W220-20 4WE-6-UO/E-W240-20 4WE-6-UOF/E-G12-20
4WE-6-UOF/E-G24-20 4WE-6-UOF/E-W110-20 4WE-6-UOF/E-W220-20 4WE-6-UOF/E-W240-20 4WE-6-V/E-G12-20
4WE-6-V/E-G24-20 4WE-6-V/E-W110-20 4WE-6-V/E-W220-20 4WE-6-V/E-W240-20 4WE-6-VO/E-G12-20 4WE-6-VO/E-G24-20
4WE-6-VO/E-W110-20 4WE-6-VO/E-W220-20 4WE-6-VO/E-W240-20 4WE-6-VOF/E-G12-20 4WE-6-VOF/E-G24-20
4WE-6-VOF/E-W110-20 4WE-6-VOF/E-W220-20 4WE-6-VOF/E-W240-20 4WE-6-Y/E-G12-20 4WE-6-Y/E-G24-20
4WE-6-Y/E-W110-20 4WE-6-Y/E-W220-20 4WE-6-Y/E-W240-20 4WE-6-YO/E-G12-20 4WE-6-YO/E-G24-20 4WE-6-YO/E-W110-20
4WE-6-YO/E-W220-20 4WE-6-YO/E-W240-20 4WE-6-YOF/E-G12-20 4WE-6-YOF/E-G24-20 4WE-6-YOF/E-W110-20
4WE-6-YOF/E-W220-20 4WE-6-YOF/E-W240-20 4WE-Q-QOF/E-G12-20 4WE-Q-QOF/E-G24-20 4WE-Q-QOF/E-W110-20
4WE-6-QOF/E-W220-20 4WE-Q-QOF/E-W240-20
液控方向閥：
DHG-04-2B2-ET-50-W110-10-AB-K DHG-04-2B2-ET-50-W240-10-AB-K DHG-04-2B3-ET-50-W110-10-AB-K
DHG-04-2B3-ET-50-W240-10-AB-K DHG-04-2D2-ET-50-W110-10-AB-K DHG-04-2D2-ET-50-W240-10-AB-K
DHG-04-2D3-ET-50-W110-10-AB-K DHG-04-2D3-ET-50-W240-10-AB-K DHG-04-3C2-ET-50-W110-10-AB-K
DHG-04-3C2-ET-50-W240-10-AB-K DHG-04-3C3-ET-50-W110-10-AB-K DHG-04-3C3-ET-50-W240-10-AB-K
DHG-04-3C4-ET-50-W110-10-AB-K DHG-04-3C4-ET-50-W240-10-AB-K DHG-04-3C5-ET-50-W110-10-AB-K
DHG-04-3C5-ET-50-W240-10-AB-K DHG-04-3C6-ET-50-W110-10-AB-K DHG-04-3C6-ET-50-W240-10-AB-K 
DHG-04-2B10B DHG-04-2B11A DHG-04-2B11B DHG-04-2B12A DHG-04-2B12B DHG-04-2B2 DHG-04-2B2A
DHG-04-2B2B DHG-04-2B2-ET-50-W110-10-AB-K DHG-04-2B2-ET-50-W240-10-AB-K DHG-04-2B2S DHG-04-2B3
DHG-04-2B3A DHG-04-2B3B DHG-04-2B3-ET-50-W110-10-AB-K DHG-04-2B3-ET-50-W240-10-AB-K DHG-04-2B3S
DHG-04-2B40A DHG-04-2B40B DHG-04-2B4A DHG-04-2B4B DHG-04-2B5A DHG-04-2B5B DHG-04-2B60A DHG-04-2B60B
DHG-04-2B6A DHG-04-2B6B DHG-04-2B8 DHG-04-2B8S DHG-04-2B9A DHG-04-2B9B DHG-04-2D2-ET-50-W110-10-AB-K
DHG-04-2D2-ET-50-W240-10-AB-K DHG-04-2D3-ET-50-W110-10-AB-K DHG-04-2D3-ET-50-W240-10-AB-K
DHG-04-2N2 DHG-04-2N3 DHG-04-3C10-50 DHG-04-3C11-50 DHG-04-3C12-50 DHG-04-3C2 DHG-04-3C2-50
DHG-04-3C2-ET-50-W110-10-AB-K DHG-04-3C2-ET-50-W240-10-AB-K DHG-04-3C3-50 DHG-04-3C3-ET-50-W110-10-AB-K
DHG-04-3C3-ET-50-W240-10-AB-K DHG-04-3C40-50 DHG-04-3C4-50 DHG-04-3C4-ET-50-W110-10-AB-K
DHG-04-3C4-ET-50-W240-10-AB-K DHG-04-3C5-50 DHG-04-3C5-ET-50-W110-10-AB-K DHG-04-3C5-ET-50-W240-10-AB-K
DHG-04-3C60-50 DHG-04-3C6-50 DHG-04-3C6-ET-50-W110-10-AB-K DHG-04-3C6-ET-50-W240-10-AB-K DHG-04-3C9-50
DHG-06-2B10B DHG-06-2B11A DHG-06-2B11B DHG-06-2B12A DHG-06-2B12B DHG-06-2B2 DHG-06-2B2A
DHG-06-2B2B DHG-06-2B2S DHG-06-2B3 DHG-06-2B3A DHG-06-2B3B DHG-06-2B3S DHG-06-2B40A DHG-06-2B40B
DHG-06-2B4A DHG-06-2B4B DHG-06-2B5A DHG-06-2B5B DHG-06-2B60A DHG-06-2B60B DHG-06-2B6A DHG-06-2B6B
DHG-06-2B8 DHG-06-2B8S DHG-06-2B9A DHG-06-2B9B DHG-06-2N2 DHG-06-2N3 DHG-06-3C10-50 DHG-06-3C11-50
DHG-06-3C12-50 DHG-06-3C2-50 DHG-06-3C3-50 DHG-06-3C40-50 DHG-06-3C4-50 DHG-06-3C5-50 DHG-06-3C60-50
DHG-06-3C6-50 DHG-06-3C9-50 DHG-10-2B10B DHG-10-2B11B DHG-10-2B12B DHG-10-2B2B DHG-10-2B3B
DHG-10-2B40B DHG-10-2B4B DHG-10-2B5B DHG-10-2B60B DHG-10-2B6B DHG-10-2B9B DHG-10-2N2 DHG-10-2N3
DHG-10-3C10-50 DHG-10-3C11-50 DHG-10-3C12-50 DHG-10-3C2-50 DHG-10-3C3-50 DHG-10-3C40-50 DHG-10-3C4-50
DHG-10-3C5-50 DHG-10-3C60-50 DHG-10-3C6-50 DHG-10-3C9-50
S-DSHG-10-3H60A220 S-DSHG-10-3H60-A220 S-DSHG-10-3H60-E-D24
抗衡閥：
J-CBEA-1-L J-PBC-A-L J-PBC-B-L J-PBC-D-L J-PBE-A-L J-PBE-B-L J-PBE-D-L J-PBG-A-L J-PBG-B-L J-PBG-D-L
溢流閥：
MRV-02-A-1-A-K MRV-02-A-1-B-K MRV-02-B-1-A-K MRV-02-B-1-B-K MRV-02-B-2-B MRV-02-P-1-A-K MRV-02-P-1-B
MRV-02-P-1-B-K MRV-02-P-3-B MRV-03-A-2-B-K MRV-03-A-2-B-L MRV-03-B-2-B-K MRV-03-B-2-B-L MRV-03-B-3-B
MRV-03-P-2-B-K MRV-03-P-2-B-L MRV-03-P-3-B MSCV-03-A-3-B
電磁控制溢流閥：
SBSG-03-1PN-1-L-30-10 SBSG-03-1PN-1-R-30-10 SBSG-03-1PN-2-L-30-10 SBSG-03-1PN-2-R-30-10 SBSG-03-1PN-3-L-30-10
SBSG-03-1PN-3-R-30-10 SBSG-06-1PN-1-L-30-10 SBSG-06-1PN-1-R-30-10 SBSG-06-1PN-2-L-30-10 SBSG-06-1PN-2-R-30-10
SBSG-06-1PN-3-L-30-10 SBSG-06-1PN-3-R-30-10 SBSG-10-1PN-1-L-30-10 SBSG-10-1PN-1-R-30-10 SBSG-10-1PN-2-L-30-10
SBSG-10-1PN-2-R-30-10 SBSG-10-1PN-3-L-30-10 SBSG-10-1PN-3-R-30-10